A Study on the Preparation of the Eco-friendly Carbon Fibers-Reinforced Composites

Kyeongeun Choi (최경은); Min-Kang Seo (서민강)

doi:10.5714/CL.2012.14.1.058

A Study on the Preparation of the Eco-friendly Carbon Fibers-Reinforced Composites

Carbon Letters
Abbr : Carbon Lett.
2013, 14(1), pp.58-61
DOI : 10.5714/CL.2012.14.1.058
Publisher : Korean Carbon Society
Research Area : Natural Science > Natural Science General > Other Natural Sciences General

Kyeongeun Choi ¹, Min-Kang Seo ²

¹전주교육대학교
²(재) 한국탄소융합기술원

Accredited

ABSTRACT

In this work, the effect of catalysts on the mechanical properties of carbon fibers-reinforced epoxy matrix composites cured by cationic latent thermal catalysts, i.e., N-benzylpyrazinium hexafluoroantimonate (BPH) was studied. Differential scanning calorimetry was executed for thermal characterization of the epoxy matrix system. Mechanical interfacial properties of the composites were studied by interlaminar shear strength (ILSS), critical stress intensity factor (KIC), and specific fracture energy (GIC). As a result, the conversion of neat epoxy matrix cured by BPH was higher than that of one cured by diaminodiphenyl methane (DDM). The ILSS, KIC, GIC, and impact strength of the composites cured by BPH were also superior to those of the composites cured by DDM. This was probably the consequence of the effect of the substituted benzene group of BPH catalyst, resulting in an increase in the cross-link density and structural stability of the composites studied.

KEYWORDS

carbon fibers-reinforced composites, catalyst, N-benzylpyrazinium hexafluoroantimonate, mechanical interfacial properties

Citation status

This is the result of checking the information with the same ISSN, publication year, volume, and start page between the WoS and the KCI journals. (as of 2023-01-02)

Total Citation Counts(KCI+WOS) (8) This is the number of times that the duplicate count has been removed by comparing the citation list of WoS and KCI.

* References for papers published after 2023 are currently being built.

[book] Inoue S / 1967 / Ring-opening polymerization / McGraw-Hill

[journal] Lee SD / 1996 / Arenesulfonates as non-salt-type latent thermal initiators for cationic polymerization / Macromolecules 29 : 3317~

[journal] Abu-Abdoun II / 1992 / Cationic photopolymerization of cyclohexene oxide / Eur Polym J 28 : 73~

[book] May CA / 1988 / Epoxy resins: chemistry and technology / Marcel Dekker

[journal] Crivello JV / 1980 / Photoinitiated cationic polymerization by dialkyl-4-hydroxyphenylsulfonium salts / J Polym Sci A 18 : 1021~

[journal] Gu J / 1985 / Curing of epoxy resins with diphenyliodonium salts as thermal initiators / J Appl Polym Sci 30 : 2997~

[book] Lee H / 1967 / Handbook of epoxy resins / McGraw-Hill

[book] Senturia S / 1986 / Dielectric analysis of thermoset cure, In Epoxy resins and composites IV, Advances in Polymer Science Vol. 80 / Springer : 1~

[journal] Lee SB / 1990 / (ρ-Methoxybenzyl)- and (α-methylbenzyl)-ρ-cyanopyridinium hexafluoroantimonates: activated latent thermal catalysts / Macromolecules 23 : 431~

[journal] Park SJ / 2000 / Isothermal cure kinetics of epoxy/ phenol-novolac resin blend system initiated by cationic latent thermal catalyst / J Polym Sci A 38 : 2945~

[journal] Reich B / 1978 / Reliability of plastic encapsulated semiconductor devices and integrated circuits / Solid State Technol 21 : 82~

[journal] Melliar-Smith CM / 1980 / Plastic encapsulation of silicon integrated circuits / Plast Rubber Mater Appl 5 : 49~

[journal] Park SJ / 2001 / Studies on epoxy resins cured by cationic latent thermal catalysts: the effect of the catalysts on the thermal, rheological, and mechanical properties / J Polym Sci A 39 : 187~

[journal] 서민강 / 2009 / Influence of Oxyfluorination on Physicochemical Characteristics of Carbon Fibers and their Reinforced Epoxy Composites / Macromolecular Research / 한국고분자학회 17(6) : 430~435

[book] Park SJ / 2011 / Interface science and composite, Interface science and technology Vol. 18 / Elsevier

[journal] Griffith AA / 1921 / The phenomena of rupture and flow in solids / Phil Trans R Soc Lond A 221 : 163~

[journal] Jae H. Lee / 2011 / Effects of oil absorption on the wear behaviors of carbon/epoxy woven composites / Carbon Letters / 한국탄소학회 12(4) : 249~251

[book] Morgan P / 2005 / Carbon fibers and their composites / Taylor & Francis

[book] Dowling NE / 1993 / Mechanical behavior of materials: engineering methods for deformation, fracture, and fatigue / Prentice Hall

KJCKorea
Journal Central

Carbon Letters 2023 KCI Impact Factor : 1.35 KCI-WoS Impact Factor : 6.04

A Study on the Preparation of the Eco-friendly Carbon Fibers-Reinforced Composites

ABSTRACT

KEYWORDS

Citation status

This is the result of checking the information with the same ISSN, publication year, volume, and start page between the WoS and the KCI journals. (as of 2023-01-02)

Total Citation Counts(KCI+WOS) (8) This is the number of times that the duplicate count has been removed by comparing the citation list of WoS and KCI.

* References for papers published after 2023 are currently being built.

Carbon Letters 2023 KCI Impact Factor : 1.35 KCI-WoS Impact Factor : 6.04

A Study on the Preparation of the Eco-friendly Carbon Fibers-Reinforced Composites

ABSTRACT

KEYWORDS

Statistics

Tools

Issue List

Citation status

KCI Citation Counts (6)

WoS Citation Counts (2) This is the result of checking the information with the same ISSN, publication year, volume, and start page between the WoS and the KCI journals. (as of 2023-01-02)

Total Citation Counts(KCI+WOS) (8) This is the number of times that the duplicate count has been removed by comparing the citation list of WoS and KCI.

REFERENCES (19) * References for papers published after 2023 are currently being built.

Search PDF

Citation

This is the result of checking the information with the same ISSN, publication year, volume, and start page between the WoS and the KCI journals. (as of 2023-01-02)

* References for papers published after 2023 are currently being built.